Fuel in Oil

coondawg · 02-13-2007, 12:26 PM

Yesterday I noticed my oil pressure on my 02 duramax was lower than normal, so I pulled into the place that services my trucks and the technician tells me that my truck is about five quarts over full. Come to find out there was deisel fuel in the oil. Called the dealership where I purchased the truck and they informed me that I had bad injectors and that they would fix the problem under warraty and that GM had a recall on them and was extending te warranty to 200,000thousand miles. Anyone expereinced this and what should I check when I pick up my truck. They are replacing all of the injectors and tubes.

**05_LLY** · 02-13-2007, 12:38 PM

Sounds right, the early trucks were sort of known for bad injectors, it is a time involved process on a lb7 engine but not to hard. They have to remove both valve covers to change the injectors so you should be able to see that!

Todd E · 02-13-2007, 03:41 PM

05LLY.............

Not intending to hijack, but what's normal oper oil pressure for an LLY?

Mine will start out a lil over 60 and after couple of miles is running down below 60.....at......about.......45......I guess(not looking at gauge while on puter). Is it normal for it to fall off like that?

Still learning bout my truck !!!

**05_LLY** · 02-13-2007, 04:15 PM

Yeah you oil psi sounds about right! it should idle between 15-30 psi depending on temp except on start up where ive seen mine as high as 80 when cold!

delawitt · 02-13-2007, 05:38 PM

A good rule of thumb on oil pressure is no less than 10lbs per 1000 RPM any less you should be concerned

Todd E · 02-13-2007, 06:42 PM

Thanks, ya'll.

coondawg · 02-26-2007, 10:51 AM

Finally Got my truck back last Friday. All injectors were replaced under warranty. I looked under the hood before leaving the dealership and was shocked to find that the fuel filter had not been changed. Service manager told me that GM does not include the filter under this warranty repair. I would think any time you work on the fuel system you should replace the filter. To me thats like putting on dirty cloths after bathing.

**Diesel Nut** · 03-01-2007, 11:00 PM

That about makes sense. Good thing they didn't change it and charge you. Last time I called to get an estimate it was $170 including parts to change the filter.

whitebull · 03-01-2007, 11:44 PM

This is new info. to me. I also have an 02. Can you give me the re-call # or any more information ?

Jessie Harbin Jr · 01-18-2008, 05:40 PM

It is a special policy from GM Special Coverage Adjustment - Injectors-Replace #04039B that was released in November of 2007. Lately I've been getting a couple of diesel's back with high fuel return rate (white smoke) and the only cure is to replace all 8 injectors, but your vehicle has to fit under the specifications to do so, plus the dealership has to perform an injector balance test and flow rate test in order for GM to pay for new injectors in a truck, under certain conditions I've seen some customers whom have contaminated their fuel systems have to shell out $5,000+ in repairs because they've voided their warranty